Carraro axle and transmission parts

Categories

07/10/2026 27

JCB JS200–JS260 Monitor Messages: What They Mean and What to Check

On JCB JS200, JS210, JS220, JS240 and JS260 tracked excavators with the AMS control system, the monitor in the cab shows the working mode, the time, gauges for oil temperature, coolant temperature and fuel level, and warnings in the message line. Each message first of all points to a real problem: low fuel or coolant, a blocked filter, overheating. But if a message stays on after the cause has been put right, the sensor, wiring or controller is at fault. Below is what each message means and what to check, based on Section C of JCB service manual 9803/6400.

07/10/2026 34

JCB JS200–JS260 Track Tension: How to Check the Sag and Adjust the Tracks

Track tension on the JCB JS200, JS210, JS220, JS240 and JS260 tracked excavators should be checked every shift. With the track raised off the ground, the gap between the underside of the track frame and the top of the track shoe at the fourth bottom roller from the front should be 275–295 mm on hard ground and 320–340 mm on soft sand and sticky clay. Tension is adjusted with grease through the valve on the track adjuster cylinder. The procedure below follows Section 3 of JCB service manual 9803/6400.

07/10/2026 22

JCB 3CX and 4CX Dipper Ram Creep: Causes, Ram Creep Tests and Repair

If the dipper of a JCB 3CX or 4CX backhoe loader drops on its own under load, there are three possible causes: a leaking piston seal in the ram, spool leakage in the excavator valve section, or a leaking auxiliary relief valve (ARV) in that section. The JCB service manual gives a test procedure that identifies the culprit before the ram is removed and stripped. Below are the test sequence, the permitted creep and the repair rules from Section E of service manual 9803/3290.

07/10/2026 27

JCB 3CX and 4CX Hydraulic Oil: HP32 or HP46, System Capacity and Changing the Oil

For the hydraulic system of JCB 3CX and 4CX backhoe loaders, the JCB service manual recommends ISO VG32 oil — JCB Hydraulic Fluid HP32 — at air temperatures below +38 °C. The more viscous ISO VG46, JCB High Performance Hydraulic Oil, is for air temperatures above +38 °C only. Machines with Advanced EasyControl joysticks need a separate all-season HV class oil, JCB Multigrade Anti Shear. The hydraulic system holds approximately 130 litres. The oil is changed every 2000 hours and the filter at every 500-hour service.

07/10/2026 33

JCB 3CX and 4CX Antifreeze: Which Coolant to Use, How Much and How to Change It

On JCB 3CX and 4CX backhoe loaders with the JCB Dieselmax engine, the coolant is renewed every two years, at the 2000-hour service. The cooling system holds 18.5 litres. The JCB service manual calls for an ethylene glycol antifreeze to ASTM D6210 with corrosion inhibitors and rules out organic acid technology (OAT) products. The standard mix is 50%, which gives protection down to −40 °C. Below we cover choosing, checking and changing the antifreeze as described in Section 3 of JCB service manual 9803/3290.

Default Name Model

188710-150

Brake friction disc 188710-150 Carraro, aftermarket

In stock

0,00 ₺

133757

Brake piston O-ring 133757 Carraro, genuine

In stock

0,00 ₺

139231

Brake piston O-ring 139231 Carraro, genuine

In stock

0,00 ₺

141937

Brake piston O-ring, large 141937 Carraro, genuine

In stock

0,00 ₺

141939

Brake piston O-ring, small 141939 Carraro, genuine

In stock

0,00 ₺

213-4227

Circlip 213-4227 CAT, aftermarket

In stock

0,00 ₺

24785

Circlip 24785 Carraro, aftermarket

In stock

0,00 ₺

642260

Circlip 642260 Carraro, aftermarket

In stock

0,00 ₺

149306

Clutch plate kit 149306 Carraro, aftermarket

In stock

0,00 ₺

068911

Crown wheel and pinion 068911 Carraro, aftermarket

In stock

0,00 ₺

68473

Crown wheel and pinion 68473 Carraro, aftermarket

In stock

0,00 ₺

140478

Differential casing 140478 Carraro, aftermarket

In stock

0,00 ₺

113879

Differential friction disc 113879 Carraro, aftermarket

In stock

0,00 ₺

113883

Differential friction disc 113883 Carraro, aftermarket

In stock

0,00 ₺

066161

Differential gear kit 066161 Carraro, aftermarket

In stock

0,00 ₺

85812301

Differential washer 85812301 Carraro, aftermarket

In stock

0,00 ₺

9W9915

Engine mount 9W-9915 CAT, aftermarket

In stock

0,00 ₺

VOE11884790

Engine mount VOE11884790 Volvo, aftermarket

In stock

0,00 ₺

113880

LSD differential plate 113880 Carraro, aftermarket

In stock

0,00 ₺

028500

O-ring 028500 Carraro, aftermarket

In stock

0,00 ₺

028600

O-ring 028600 Carraro, aftermarket

In stock

0,00 ₺

28111

O-ring 28111 Carraro, aftermarket

In stock

0,00 ₺

28131

O-ring 28131 Carraro, aftermarket

In stock

0,00 ₺

85808298

O-ring 85808298 Carraro, aftermarket

In stock

0,00 ₺

Showing 361 to 384 of 415 (18 Pages)

Carraro axle and transmission parts (page 16)