Cab glass for JCB, CAT, Volvo, Hidromek

Categories

07/10/2026 27

JCB JS200–JS260 Monitor Messages: What They Mean and What to Check

On JCB JS200, JS210, JS220, JS240 and JS260 tracked excavators with the AMS control system, the monitor in the cab shows the working mode, the time, gauges for oil temperature, coolant temperature and fuel level, and warnings in the message line. Each message first of all points to a real problem: low fuel or coolant, a blocked filter, overheating. But if a message stays on after the cause has been put right, the sensor, wiring or controller is at fault. Below is what each message means and what to check, based on Section C of JCB service manual 9803/6400.

07/10/2026 34

JCB JS200–JS260 Track Tension: How to Check the Sag and Adjust the Tracks

Track tension on the JCB JS200, JS210, JS220, JS240 and JS260 tracked excavators should be checked every shift. With the track raised off the ground, the gap between the underside of the track frame and the top of the track shoe at the fourth bottom roller from the front should be 275–295 mm on hard ground and 320–340 mm on soft sand and sticky clay. Tension is adjusted with grease through the valve on the track adjuster cylinder. The procedure below follows Section 3 of JCB service manual 9803/6400.

07/10/2026 22

JCB 3CX and 4CX Dipper Ram Creep: Causes, Ram Creep Tests and Repair

If the dipper of a JCB 3CX or 4CX backhoe loader drops on its own under load, there are three possible causes: a leaking piston seal in the ram, spool leakage in the excavator valve section, or a leaking auxiliary relief valve (ARV) in that section. The JCB service manual gives a test procedure that identifies the culprit before the ram is removed and stripped. Below are the test sequence, the permitted creep and the repair rules from Section E of service manual 9803/3290.

07/10/2026 26

JCB 3CX and 4CX Hydraulic Oil: HP32 or HP46, System Capacity and Changing the Oil

For the hydraulic system of JCB 3CX and 4CX backhoe loaders, the JCB service manual recommends ISO VG32 oil — JCB Hydraulic Fluid HP32 — at air temperatures below +38 °C. The more viscous ISO VG46, JCB High Performance Hydraulic Oil, is for air temperatures above +38 °C only. Machines with Advanced EasyControl joysticks need a separate all-season HV class oil, JCB Multigrade Anti Shear. The hydraulic system holds approximately 130 litres. The oil is changed every 2000 hours and the filter at every 500-hour service.

07/10/2026 33

JCB 3CX and 4CX Antifreeze: Which Coolant to Use, How Much and How to Change It

On JCB 3CX and 4CX backhoe loaders with the JCB Dieselmax engine, the coolant is renewed every two years, at the 2000-hour service. The cooling system holds 18.5 litres. The JCB service manual calls for an ethylene glycol antifreeze to ASTM D6210 with corrosion inhibitors and rules out organic acid technology (OAT) products. The standard mix is 50%, which gives protection down to −40 °C. Below we cover choosing, checking and changing the antifreeze as described in Section 3 of JCB service manual 9803/3290.

Default Name Model

CTRS0006

428E right upper door glass 1039x909 mm CAT, aftermarket

In stock

0.00 ₺

CTRS0038

428E upper rear window 980x889 mm CAT, aftermarket

In stock

0.00 ₺

CTRS0007

428E/432E/434E left side window CAT, aftermarket

In stock

0.00 ₺

CTRS0032

428F2/432F2 left side window 784x1017 mm CAT, aftermarket

In stock

0.00 ₺

CTRS0022

428F2/432F2 left side window CAT, aftermarket

In stock

0.00 ₺

CTRS0031

428F2/432F2 rear window 928x1383 mm CAT, aftermarket

In stock

0.00 ₺

CTRS0030

428F2/432F2 right side window 784x1017 mm CAT, aftermarket

In stock

0.00 ₺

CTRS0023

428F2/432F2 right upper door glass 1066x773 mm CAT, aftermarket

In stock

0.00 ₺

CTRT0006

428F2/432F2 windscreen 1354x990 mm CAT, aftermarket

In stock

0.00 ₺

CTRS0023

432F right upper door glass 1066x773 mm CAT, aftermarket

In stock

0.00 ₺

827/80226

540-140 cab roof glass 827/80226 JCB Loadall, aftermarket

In stock

0.00 ₺

JCBS0021

540-140 upper door glass 333/D6291 JCB Loadall, aftermarket

In stock

0.00 ₺

84598730

570ST windscreen 84598730 Case, aftermarket

In stock

0.00 ₺

HYNS0068

7 series lower windscreen Hyundai, aftermarket

In stock

0.00 ₺

HYNS0053

7 series upper windscreen 1005x770 mm Hyundai, aftermarket

In stock

0.00 ₺

VLVS0008

BL61/BL71 left door glass 1139x854 mm Volvo, aftermarket

In stock

0.00 ₺

VLVS0018

BL61/BL71 left lower door glass 735x366 mm Volvo, aftermarket

In stock

0.00 ₺

VLVS0016

BL61/BL71 rear window 1304x849 mm Volvo, aftermarket

In stock

0.00 ₺

VLVS0009

BL61/BL71 right door glass 1139x854 mm Volvo, aftermarket

In stock

0.00 ₺

VLVS0019

BL61/BL71 right lower door glass 735x366 mm Volvo, aftermarket

In stock

0.00 ₺

VLVT0047

BL61/BL71 windscreen Volvo, aftermarket

In stock

0.00 ₺

333/J7019

JS205 lower windscreen 333/J7019 JCB JS, genuine

In stock

0.00 ₺

333/J7034

JS205 upper windscreen 333/J7034 JCB JS, aftermarket

In stock

0.00 ₺

CTRT0001

Laminated upper windscreen CAT, aftermarket

In stock

0.00 ₺

Showing 73 to 96 of 111 (5 Pages)

Cab glass (page 4)